Viewpoint: Turnarounds to support Asia product margins

Spanish Market: Oil products
24/12/19

Asia-Pacific oil product refining margins fell late in 2019, but tighter supply and a heavy turnaround schedule in the Mideast Gulf may support the market in the first quarter of 2020.

The outlook for gasoil has weakened in the past few months, confounding expectations. Middle distillates had been poised to be the best-performing product in 2020 thanks to structural support from the International Maritime Organisation (IMO) 2020 regulations, which reduce the maximum sulphur content in marine fuels from 3.5pc to 0.5pc on 1 January.

The IMO 2020 rules had been expected to provide two layers of support — by increasing demand for marine gasoil, as well as potentially diverting feedstock supplies to low-sulphur marine fuel production and away from gasoil-producing secondary units.

But poor fundamentals have weighed on margins, with gasoil's premium to Dubai crude narrowing to a more than six-month low towards the end of November.

Demand weakness

Supply is outstripping demand, notably because of weaker consumption in Indonesia and India. Domestic demand in India has been hit by an economic slowdown, sending exports to a record high of 864,000 b/d in September. And diesel imports to Indonesia, the region's biggest importer, fell by 36pc in January-September after the government required transport fuels to contain 20pc biodiesel (B20). Indonesia's diesel fuel imports are expected to fall further after a B30 mandate is implemented in January 2020.

Light distillate margins have been mixed, with naphtha refining margins well supported by a heavy turnaround schedule in the Middle East and firming prices of propane, an alternative cracker feedstock. Gasoline margins have also performed strongly thanks to seasonal demand, but added supply from new refineries have pressured prices.

Malaysia's 300,000 b/d Pengerang refinery complex has offered two medium-range cargoes in November-December, while Chinese firm Hengyi's 175,000 b/d Brunei refinery has offered three medium-range cargoes for loading in the same period. Rising gasoline exports from China are also expected to weigh on prices, as two new private-sector 400,000 b/d refineries — Hengli's Changxing plant in Dalian and Rongsheng-led ZPC's refinery in Zhoushan — ramp up to full capacity.

Heavy hit

Dynamics are sharply different towards the bottom of the barrel. High-sulphur fuel oil margins have fallen to the lowest level in over 10 years because of a sharp reduction in demand for high-sulphur marine fuel oil (HSMFO), which has been hit by the switch to lower sulphur fuels in the run-up to IMO 2020. Sales of the product in Singapore fell sharply to 2.78mn t in October, the lowest level this year and down by almost 28pc from October 2018.

But a heavy turnaround schedule in the Mideast Gulf could support some product prices in the first quarter. Satorp, the joint venture between Total and state-owned Saudi Aramco that operates the 460,000 b/d Jubail refinery in Saudi Arabia, will have a partial shutdown in the first quarter of 2020. Abu Dhabi's state-owned Adnoc, another key exporter of naphtha, is planning to take two crude distillation units (CDUs) off line for scheduled maintenance around the same period. Other Saudi refineries are also planning turnarounds but details are unclear.

Mideast Gulf exports are likely to fall year-on-year in the first quarter because of the heavier turnaround schedule. The Mideast Gulf exported an average of more than 5mn t of middle distillates, 3.4mn t of naphtha, 2.36mn t of fuel oil and slightly more than 1mn t of gasoline in January-March 2019, according to data from oil analytics firm Vortexa.

The naphtha market is expected to be most affected by the heavy maintenance plans, which have already helped send prices to a six-year high in early December. Most if not all of the Mideast Gulf's 3mn-4mn t/month naphtha exports move towards northeast Asia.

Refiners in the Middle East also export large amounts of gasoil and jet fuel, although most of the region's average 3mn-4mn t/month middle distillate exports head west of suez or towards east Africa. But the Asia-Pacific middle distillate market could still be indirectly affected, as Indian exporters may pivot west to fill the supply gap from the Mideast Gulf.

By Aldric Chew

Related news posts

Argus illuminates the markets by putting a lens on the areas that matter most to you. The market news and commentary we publish reveals vital insights that enable you to make stronger, well-informed decisions. Explore a selection of news stories related to this one.

28/04/25

Power outage hits Spanish refineries: Update

Adds new details throughout London, 28 April (Argus) — A massive power cut across the Iberian peninsula has disrupted operations at several refineries and chemical plants in Spain today. All five of Repsol's refineries have been forced to shut, a union representative for the company's workers said. This includes the 220,000 Bilbao refinery which is operated by Repsol's Petronor subsidiary. Crews are in place, securing units at the refineries. "There is sufficient autonomy in all of them to guarantee the safety of the facilities," the union representative said. Repsol has yet to respond to a request for comment. Fellow Spanish refiner Moeve said it has also halted activity at its refining and chemical plants in the country and is using back-up power generators "to guarantee the safety and control of the system". Moeve operates the 244,000 b/d Algeciras and 220,000 b/d Huelva refineries. Its 250,000 t/yr San Roque base oils plant is also shutting down. Chemicals firm Dow said all plants at its Tarragona industrial complex in Spain have been closed. The longer the power outage lasts, the longer it will take to restart integrated sites. Refineries affected by power outages normally require a 2-3 day restart period. It is unclear yet if any plants have sustained damage. Spanish transmission system operator (TSO) Red Electrica and relevant government bodies are investigating the cause of the blackout. Red Electrica said power has been restored "at substations in several areas in the north, south and west of the peninsula, and consumers in these areas are beginning to be supplied". By George Maher-Bonnett, Isabella Reimi, Alex Sands and Monicca Egoy Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Power outage hits Spanish refineries

28/04/25

Power outage hits Spanish refineries

London, 28 April (Argus) — A massive power cut across the Iberian peninsula has disrupted operations at several refineries in Spain today, sources told Argus. Spanish firm Repsol's Petronor subsidiary halted all units at its 220,000 Bilbao refinery earlier because of the power cut, with black smoke released as part of the security stoppage, market participants said. Shutdowns are also under way at Moeve's 250,000 t/yr San Roque base oils plant and at Repsol's 135,000 b/d La Coruna refinery, sources said. Flaring has been seen at Repsol's 180,000 b/d Tarragona refinery as a result of a response system being activated at the site, according to petrochemical sources. Moeve and Repsol have yet to respond to a request for comment. "The refineries need to be brought to a safe state," a trade union representative for Repsol workers said. "The crews are in place, securing the units. There is sufficient autonomy in all of them to guarantee the safety of the facilities." Chemical sites will also be affected by the power outage. The longer the power outage lasts, the longer it will take to restart integrated sites. Refineries affected by power outages normally require a 2-3 day restart period. It is unclear yet if any plants have sustained damage. By George Maher-Bonnett, Isabella Reimi and Alex Sands Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Trump works to blunt renewables growth

28/04/25

Trump works to blunt renewables growth

Washington, 28 April (Argus) — US president Donald Trump has started to impede development of renewable energy projects he sees as boondoggles, but he is facing challenges to his attempts to halt government funding and tax credits for the sector. Trump has attacked wind turbines and solar projects as part of a "Green New Scam" that should not be built, based on his preference for the fossil fuel-fired and nuclear power plants he says are more reliable and affordable. Trump selected a cabinet of like-minded individuals who oppose renewables and see little urgency to address climate change. He was elected to end the "nonsense" of building renewable resources that are heavily subsidised, make the grid less reliable and raise costs, energy secretary Chris Wright said in an interview on Earth Day. Interior secretary Doug Burgum on 16 April ordered Norwegian state-controlled Equinor to "immediately halt" construction of the 810MW Empire Wind project off New York. Trump had already ordered a freeze on future offshore wind leases , and suspending Empire Wind's permits is likely to spook investors even outside the renewables sphere. To reverse course on a fully permitted project is "bad policy" that "sends a chilling signal to all energy investment", American Clean Power Association chief executive Jason Grumet says. The US last week separately said it would impose anti-dumping duties on solar components imported from four southeast Asian countries that will range from 15pc to 3,400pc. Those duties — in effect from June to support US solar manufacturers — will be in addition to a 10pc across-the-board tariff the US imposed this month on most imports. Solar industry groups have said that steep import duties will make new installations unaffordable, stunting the industry's ability to grow. Trump has had less success in his push to axe support for renewables approved under Joe Biden. On 15 April, a federal judge ordered the administration to unfreeze billions of dollars for clean energy projects provided by the Inflation Reduction Act (IRA) and 2021 infrastructure law. The administration lacks "unfettered power to hamstring in perpetuity two statutes", judge Mary McElroy wrote. In a separate ruling on 15 April, judge Tanya Chutkan prohibited the administration from suspending $14bn in grants distributed to nonprofits under the IRA for a greenhouse gas reduction programme. The administration is appealing both rulings. Targeting the windfall Trump could further undermine the growth of renewables by convincing Republicans in Congress to use an upcoming filibuster-proof budget package to repeal or narrow the IRA's tax credits for wind, solar and other clean energy projects. Critics of that law see the potential for $1 trillion in savings by repealing its tax credits, which could offset the costs of more than $5 trillion in planned tax cuts. But there appear to be enough votes in each chamber of Congress to spare at least some of the IRA's energy tax credits. In the Senate, where Republicans can only afford to lose three votes, Alaska's Lisa Murkowski and three other Republicans signed a joint letter this month saying "wholesale repeal" of the tax credits would fuel uncertainty and undermine job creation. In the House of Representatives, where Republicans have a similarly slim majority, 21 Republicans voiced concerns earlier this year about repealing all of the tax credits. Renewables are on track to overtake natural gas as the largest source of US electricity by 2030 — assuming the tax credits and climate rules enacted under Biden remain intact — the EIA stated this month in its Annual Energy Outlook . The amount of power from renewables under the EIA's existing policy baseline by 2035 will increase by 135pc to 2.8bn MWh, while gas-fired power will decline by 14pc to 1.6bn MWh over the same time period. By Chris Knight Baseline US net power generation Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

US tariffs create uncertain jet fuel outlook

25/04/25

US tariffs create uncertain jet fuel outlook

Houston, 25 April (Argus) — US airlines are signaling an uncertain outlook for jet fuel demand, with most withdrawing 2025 financial guidance because President Donald Trump's evolving tariff plans have made it difficult to predict travel demand. Delta Air Lines , American Airlines , Southwest Airlines and Alaska Airlines all withdrew financial guidance for the full year when reporting first-quarter earnings this month. Global economic uncertainty prompted United Airlines to provide two outlooks , one based on a weaker but stable economy and a second scenario in which the US falls into a recession. The uncertain demand outlook comes even as jet fuel costs are 11-15pc cheaper than a year earlier, with prices projected to fall to a 4-year low in 2025 . Much of the uncertainty stems from Trump's high and repeatedly changing tariff levels. He has imposed an across-the-board 10pc on imports from most trading partners, 25pc on some imports from Canada and Mexico and 145pc on most imports from China — and separately, a 25pc tariff on imported steel, aluminium, cars and auto parts. Beijing has responded with a 125pc tariff on imports from the US. The growing trade war has prompted the IMF to significantly lower its outlook for global economic growth in 2025-26. With no clear path on how to navigate the changing political and economic landscape, businesses and consumers have grown more cautious. Domestic and international air travel began to falter last month as Trump rolled out his trade policies. US airline passenger volumes declined by 15pc to 16.48mn passengers in the week ended 8 March, down from an eight-month high in the week prior. Brewing anti-American sentiment and concern about US immigration policy also may be lowering global demand for air travel to the US. The number of European travelers to the US totalled 1.03mn in March, lower by 15pc from the same month last year. This was the first time that European arrivals in the US fell on the year since March 2021, during the Covid-19 pandemic. By Craig Ross Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Phillips 66 ups Sweeny crude switching capacity: Update

25/04/25

Phillips 66 ups Sweeny crude switching capacity: Update

Adds CEO comment from earnings call Houston, 25 April (Argus) — US independent refiner Phillips 66 completed a project in the first quarter that allows it to adjust more of the crude slate at its 265,000 b/d Sweeny refinery in Old Ocean, Texas. The project will allow the company to switch about 40,000 b/d between heavy and light crude, Phillips 66 said today in an earnings release. The flexibility project was completed during a first quarter turnaround. Phillips 66 plans to run additional crude from the Permian basin in west Texas and eastern New Mexico through Sweeny, depending on market conditions, chief executive Mark Lashier said on an earnings call. The lighter crude from the Permian will displace imported heavy crude, he said. Several US refiners are exploring ways to run more lighter crude grades in the wake of new US tariffs and other actions that may limit the supply of heavier and medium grade crudes imported from trading partners. By Eunice Bridges Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Business intelligence reports

Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.

Learn more