Calif judge blocks P66 RD output until permit fix

Spanish Market: Biofuels, Crude oil
13/10/23

The largest US refinery conversion to renewable diesel (RD) production must resolve permitting issues before it can operate, a California judge clarified yesterday.

The Superior Court of Contra Costa County yesterday ordered that construction may continue on the 67,000 b/d Rodeo Renewed project but that the facility may not operate until Phillips 66 and Contra Costa County resolve a trio of potential deficiencies in its environmental review that allowed the project.

The judgment clarified a previous decision that allowed conversion work already underway to continue but did not address whether the project could also operate once completed. Phillips 66 had sought an order allowing the plant to operate as that permitting work was underway.

Phillips 66 may complete construction without interruption but the judgment leaves uncertain when a major new consumer of biofuel feedstocks and source of renewable diesel might begin ramping up operations. The original permitting work, under the California Environmental Quality Act, took roughly a year to review and receive county approval in May 2022.

Phillips 66 plans to end crude processing at the refinery ahead of a first quarter 2024 start of commercial operations at the facility.

"We are confident the issues identified by the court will be resolved and take seriously our commitment to safe and environmentally sound operations," a Phillips 66 spokesman said today.

Judge Edward Weil in August set aside Contra Costa County's approval of an environmental impact report essential to the refinery conversion's land use permit to address three issues raised by environmental organizations. The county must consider the environmental impact of a third-party feedstocks terminal, odor mitigation associated with renewable diesel production and the combined effect of the full conversion and a previously approved and operating 12,000 b/d renewable diesel unit at the facility, issues not suitably addressed in the approved permit, according to the court.

Weil determined that the previous judgment should be clearer following oral arguments held yesterday. Citizens for a Better Environment and the Center for Biological Diversity (CBD) had pressed over the past two months to specifically block operations pending the review.

"Communities long suffering from refinery pollution have every right to demand maximum protections against toxic emissions and foul odors, and the county needs to secure them," CBD attorney Hollin Kretzmann said in a statement.

Renewable diesel consumption generates nearly 40pc of new credits under California's Low Carbon Fuel Standard. Rising supplies of the fuel, which can seamlessly replace petroleum diesel in most fuel systems, have contributed to a record and growing volume of unused LCFS credits that have helped cut spot credit prices by more than half since early 2021.

US renewable diesel consumption has in turn dramatically increased supplies of federal renewable identification numbers (RINs) used to comply with the US Renewable Fuel Standard, blunting the need to blend higher concentrations of ethanol and weighing on D4, D5 and D6 RIN prices.

By Elliott Blackburn

Related news posts

Argus illuminates the markets by putting a lens on the areas that matter most to you. The market news and commentary we publish reveals vital insights that enable you to make stronger, well-informed decisions. Explore a selection of news stories related to this one.

27/12/24

Viewpoint: SE Asian IMO2 MRs to rise on EU policy

London, 27 December (Argus) — Rates for specialised Medium Range (MR) tankers in southeast Asia will be driven up in 2025 by changes in EU policy on deforestation, higher biofuels blending mandates, and new mandates in the aviation sector, all of which will support exports of biodiesels, feedstocks and palm oil. Demand for specialised MRs in southeast Asia is ruled by exports of palm oil to Europe and the US Gulf coast. Palm oil does not usually need to travel on IMO2 ships and can be moved on IMO3 vessels. But it is often moved as a part-cargo of between 5,000-15,000t so is often picked up by IMO2 or IMO2/3 vessels, which are more suitable as they have a higher number of segregated tanks. Kpler data show around 6.3mn t of palm oil was exported from Indonesia and Malaysia to the US Gulf and Europe in the January-November 2024 period. Palm oil deliveries from southeast Asia have been trending lower since 2020 with the product becoming less popular in Europe because of deforestation issues. On 4 December, an agreement was reached between the European Council and the European Parliament to delay the application of the EU Deforestation Regulation (EUDR) by one year. This means larger companies will not be required to prove that their products, such as palm oil, did not contribute to deforestation until 30 December 2025. This has averted a potential rapid loss in palm oil exports to Europe in 2025 but there will probably be a substantial decline in exports later in the year as businesses prepare for the EUDR. In the short term, the decision to postpone the EUDR will probably boost cargo numbers heading to Europe as traders had been holding off for clear regulatory guidance. This will support freight rates for IMO2 MRs in the new year by pulling more IMO2/3s and IMO3s away from the market and by increasing the number of part cargoes available for IMO2s. Feedstock exports ramp up Indonesia and Malaysia also export many specialised products that require IMO2s, such as waste based feedstocks palm oil mill effluent (POME), palm fatty acid distillate (PFAD) and used cooking oil (UCO), as well as finished biodiesels like Ucome. Kpler puts exports of these products to Europe at around 2.8mn t in the first 11 months of 2024, with POME cargoes making up 42pc of all shipments or around 1.2mn t. POME was included in Annex IX Part A of the EU's renewable energy directive (RED), meaning member states can count it twice towards their renewable energy goals. Exports of feedstocks and biodiesels to Europe will probably rise in 2025 as blending mandates rise and because of a reduction in the carryover of emissions tickets in Germany and the Netherlands. Argus estimates European demand for biodiesel Pomeme to rise by around 36pc on the quarter in first three months of 2025 to around 3.5mn litres. Higher requirements for biofuels and feedstocks in Europe should push up demand for products like POME, PFAD, and UCO from Malaysia and Indonesia and support higher IMO2 demand in southeast Asia. But this could be tempered by an Indonesian ruling to include an export permit for POME and PFAD that requires participants to fulfil their cooking oil domestic market obligation. SAF mandates begin in Europe Exports of HVO and SAF from Singapore to Europe also make up part-cargo demand for IMO2 MRs. Argus forecasts European HVO demand will rise by 85pc on the quarter to 2,582mn l in the first three months of 2025. New 2pc SAF mandates in the EU and UK in 2025 will provide a sizable rise in SAF demand. This should spur a jump in cargoes loading from Singapore — driving up demand for part-cargo space on IMO2 MRs. By Leonard Fisher-Matthews Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Viewpoint: Policy doubts hit Australia's biofuel sector

27/12/24

Viewpoint: Policy doubts hit Australia's biofuel sector

Sydney, 27 December (Argus) — Australia's biofuels sector has garnered significant interest during the first 2½ years of the current federal Labor government, but uncertainty over key policy support measures has stymied investment and led developers to question whether 2025 will be a year of reform. Labor secured its first majority government since 2007 in the mid-2022 election and subsequently pledged to cut Australia's greenhouse gas emissions by 43pc on 2005 levels by 2030. But the country is not on track to meet this ambitious target because of slow progress decarbonising its electricity and transport sectors. Biofuels have become increasingly popular, given decarbonising hard-to-abate transport industries is seen as key to reaching the 2030 goal. Canberra has committed to a low carbon liquid fuels (LCLF) standard, which the industry views as crucial to enabling investment in processing, refineries and new feedstock crops. In its May 2024 budget, the federal government expressed a desire to develop sustainable aviation fuel (SAF) and renewable diesel (HVO) industries. The outcomes of consultations are expected to be released imminently. On the demand side, a regulatory impact analysis of the costs and benefits associated with mandates for LCLF has been promised, but no timeframe has been released. Domestic refiners Ampol and Viva, as well as BP at its former Kwinana refinery, have expressed interest in biofuel production but all require certainty on demand and supply-side support mechanisms. Australian bioenergy developer Jet Zero and a consortium including major airlines aim to build a 113mn litres/yr plant in the northern part of Queensland state, but initial engineering for the concept has not yet been completed. The consortium plans to convert bioethanol from domestic agricultural byproducts like sugarcane molasses into SAF and HVO through the alcohol-to-jet pathway, with production expected to start in 2027. Jet Zero is also planning to produce SAF through the Hydrotreated Esters and Fatty Acids (HEFA) production pathway in a 50:50 joint venture with Aperion Bioenergy. But the project, which is still in its feasibility stage, is facing hurdles in pricing the feedstock offtake agreements or term contracts. Complicating the picture, heavy transport is now showing greater signs of electrification, as demonstrated by iron ore producer Fortescue's major order for new electric haul trucks. Regardless, the introduction of new safeguard mechanism laws requiring large emitters to reduce pollution has led Australia's fuel companies to increase HVO sales, with 500,000l contracts now signed on a regular basis despite the higher costs. Australian coal mining firm Stanmore has tested a 20pc HVO blend at its Bowen basin Poitrel mine, demonstrating an increasing acceptance of biofuels by customers. Ampol and Viva both sell fatty acid methyl esters (Fame) based biofuel blends at 5pc, 10pc and 20pc. Ampol has two projects in the pipeline: a co-processing facility that would supply up to 60mn l/yr by 2026 and the Brisbane renewable fuels joint venture, which would be a larger project of 0.5bn-1bn l/yr and is due for a final investment decision by late 2025. Viva has been less forthcoming about its plans for biofuel production since it announced a new biofuel blending venture at its 120,000 b/d Geelong refinery in 2023. There will be a federal election no later than mid-May 2025 and both major parties are keen to enhance their green image while supporting regional communities and manufacturing jobs. New regulatory support is crucial if Australia is to transition from supplying significant quantities of feedstock for biofuels to other countries, particularly tallow and canola seed, to producing its own renewable fuels. Australia's increasing reliance on imported oil products and foreign crude, along with a worsening geopolitical backdrop, has started to raise concerns in Canberra. This could be the deciding factor in whether the government will create the required regulatory environment for a local biofuels industry to thrive. By Tom Major and Tom Woodlock Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Viewpoint: MEH-Midland spread to remain wider in 2025

26/12/24

Viewpoint: MEH-Midland spread to remain wider in 2025

Houston, 26 December (Argus) — WTI Houston's premium to WTI in Midland, Texas, is set to hold at 50¢/bl or wider in 2025, boosted by swelling volumes headed toward the Gulf coast as Houston grows in importance as a center for price discovery. The locational spread between WTI Houston and Midland rose steadily throughout 2024, averaging 49¢/bl year-to-date and widening as high as $1.41/bl during the June trade month as the 1.5mn b/d Wink-to-Webster pipeline was taken offline for repairs. In 2023, the spread averaged 21¢/bl. Trading activity for WTI at Oneok's Magellan East Houston (MEH) terminal — both in the physical and financial markets — climbed to all-time highs in 2024. Reported trade month volumes for WTI Houston swelled to 1.26mn b/d during the December trade cycle, a high for the year, and just 0.8pc below its previous record. On 16 December, WTI Houston trade closed the day at 153,000 b/d for the January trade cycle, the highest single-day trade volume in the history of Argus assessments of the grade. In financial markets, WTI Houston trade activity broke records in 2024, with open interest on CME's WTI Houston futures contract climbing to an all-time high of 412,519 lots — each 1,000 bl — on 21 November. MEH demand up despite export slowdown Trading activity broke records even as US crude exports slowed in the latter half of 2024 on Chinese economic woes that dampened Asian demand. New Chinese stimulus initiatives, namely relaxed fiscal and monetary policy , are meant to reverse that trend, but it remains to be seen if the efforts will work. Further challenges weighing on the US export market are a strengthening dollar combined with a high degree of uncertainty surrounding president-elect Donald Trump's proposed tariff plans, which feature ratcheting-up trade tensions with China even more. Multiple projects to add Permian takeaway capacity at the Texas Gulf coast are in various stages of planning, which could eventually open the window for ever-larger WTI export volumes, and further support WTI Houston against Midland. But industry participants have grown skeptical of the need for new export terminals or other projects. Midstream companies showed little enthusiasm for pitching new coast-bound pipelines from the Permian basin in their end-of-year investor reports . Key firms previously sought more takeaway capacity before the Covid-19 pandemic, when WTI Houston premiums to WTI in Midland consistently topped $1/bl, which would help recoup pipeline construction costs. As it stands, the roughly 3mn b/d total available pipeline capacity from the Permian basin to the Houston area is likely to remain static in coming years. This status quo for onshore infrastructure will help prop open the Houston-Midland WTI premium for the coming year, even if export demand fails to picks up in 2025. By Gordon Pollock WTI Houston-WTI Midland spread Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Viewpoint: US tariffs may push more Canadian crude east

26/12/24

Viewpoint: US tariffs may push more Canadian crude east

Singapore, 26 December (Argus) — Canada may divert crude supplies from the US to Asia-Pacific via the Trans Mountain Expansion (TMX) pipeline in 2025, should president-elect Donald Trump impose tariffs on Canadian imports. Trump has declared that he will implement a 25pc tax on all imports originating from Canada after he is sworn into office on 20 January. This will effectively add around $16/bl to the cost of sending Canadian crude to the US, based on current prices, and impel US refiners to cut their purchases. The US imported 4.57mn b/d of Canadian crude in September, according to data from the EIA. Canadian crude producers are expected to turn to Asian refiners in their search for new export outlets. This is especially after Asian refiners gained easier access to such cargoes following the start-up of the 590,000 b/d TMX pipeline in May. The new route significantly shortens the journey to ship crude from Canada to Asia. It takes about 17 days for a voyage from Vancouver to China, compared with 54 days from the US Gulf coast to the same destination. China has become the main outlet for Asia-bound shipments from Vancouver, accounting for about 87pc of the 200,000 b/d exported over June-November, according to data from oil analytics firms Vortexa and Kpler (see chart). But even if the full capacity of the TMX pipeline is utilised to export crude to Asia from Vancouver, it will still only represent a fraction of current Canadian crude exports to the US. Vancouver sent just 154,000 b/d via the TMX pipeline to US west coast refiners over June-November, Vortexa and Kpler data show. Meanwhile, latest EIA figures show more than 2.63mn b/d of Canadian crude was piped into the US midcontinent in September, while US Gulf coast refiners imported 469,000 b/d. This means Canadian crude prices will likely come under downward pressure from higher costs for its key US market, should Trump's proposed tariffs come to pass. This will further incentivise additional buying from Chinese customers, as well as other refiners based elsewhere in Asia-Pacific. India, South Korea, Japan, and Brunei have already imported small volumes of Canadian TMX crude in 2024. A question of acidity But other Asian refiners have so far been reluctant to step up their heavy sour TMX crude imports because of concerns over the high acidity content. China has been mainly taking Access Western Blend (AWB), which has a total acid number (TAN) as high as 1.6mg KOH/g. Acid from high-TAN crude collects in the residue at the bottom of refinery distillation columns where it can corrode units, which deters many refineries from processing such grades. But Chinese refiners have been able to dilute the acidity level by blending their AWB cargoes with light sweet Russian ESPO Blend, allowing them to save costs compared to buying medium sour crude from the Mideast Gulf. Cold Lake, the other grade coming out of the TMX pipeline, has a lower TAN and is currently popular with refiners on the US west coast. But higher costs from potential tariffs could prompt Cold Lake exports to be redirected from the US to buyers in South Korea, Japan, and Brunei — which had all bought the grade previously. Canadian crude appears to have so far displaced medium sour grades in Asia-Pacific, and this trend is expected to continue should TMX crude flows to the region climb higher in 2025. More Canadian crude heading to Asia may displace and free up more Mideast Gulf medium sour supplies to buyers in other regions, including US refiners looking for replacements to their Canadian crude imports. This will also limit the flows of other arbitrage grades like US medium sour Mars crude to Asia-Pacific, which has already seen exports to Asia dwindle in 2024. Opec+ is also due to begin unwinding voluntary production cuts in April 2025, which means Canadian producers will likely have to lower prices sufficiently to attract buyers from further afield. By Fabian Ng TMX exports from Vancouver (b/d) Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Viewpoint: Ethanol producers face higher costs in 2025

24/12/24

Viewpoint: Ethanol producers face higher costs in 2025

London, 24 December (Argus) — European ethanol producers may face rising output costs in 2025 as a poorer harvest season will push feedstock prices up, while other factors such as greenhouse gas (GHG) emission values could affect the price of finished products. Unfavourable weather conditions have led to a poor 2024-25 harvest, particularly for wheat. In Ukraine, Europe's largest wheat exporter excluding Russia, Argus forecasts wheat production will drop to 22.3mn t during 2024-25 , down from a five-year average of 24.7mn t. Corn supply from the country for 2024-25 is projected to fall to 22.9mn t, down from 31.5mn t in the previous season, according to Argus data. France — Europe's largest producer of ethanol — has cut its wheat production outlook for 2024-25 because of wet weather. And rainfall in other parts of Europe has affected corn toxin levels, potentially leading to poorer quality ethanol. This will likely weigh on ethanol output in 2025 as it will strain feedstock supplies, push production costs up and squeeze margins for producers. Nuts 2 It comes as markets are still waiting for an update on level 2 in the nomenclature of territorial units for statistics greenhouse gas (GHG) emission values — the so called Nuts 2 values. To determine the GHG emissions from growing crops in the EU, the bloc's Renewable Energy Directive (RED) allows the use of typical units that represent the average GHG value in a specific area. On the back of the implementation of the recast of RED (RED II), the European Commission requested an update of the Nuts 2 GHG values. Member states have to prepare new crop reports to be assessed by the commission. But reports have been slow to emerge, while those that have been submitted face a lengthy review. Producers rely on GHG values to calculate the GHG savings of end-products, but default RED values currently in place are significantly lower than the typical GHG values from Nuts 2. While this is unlikely to have long-term effects beyond 2025, in the current context finding values that meet market participants' criteria has been difficult for some, which may support prices. Rising demand Demand for waste-based and ethanol with higher GHG savings should increase in 2025 as a result of policy changes, after lower renewable fuel ticket prices in key European markets kept buying interest in check in 2024. Tickets are generated by companies supplying biofuels for transport. They are tradeable and can help obligated parties meet renewables mandates. The decline in prices for GHG tickets in Germany — the main demand centre for minimum 90pc GHG savings ethanol — weighed on ethanol consumption in 2024, squeezing the differential to product with lower GHG savings. The premium averaged around €17/m³ ($17.7/m³) from 1 January-1 December 2024, down from around €43/m³ during the same period in 2023. But an increase in Germany's GHG quota in 2025, coupled with Germany's decision to pause the use of GHG certificates carried forward from previous compliance years towards the 2025 and 2026 blending mandate, should increase physical blending and lift premiums for ethanol with high GHG savings, according to market participants. Meanwhile, the Netherlands' ministry of infrastructure and water management's plan to reduce the amount of Dutch tickets that obligated companies will be able to carry forward to 2025 to 10pc from 25pc may have little effect on Dutch double-counting ethanol premiums in 2025. Participants expect steady premiums, despite slightly higher overall blending targets. The Argus double-counting ethanol fob ARA premium to crop-based ethanol fob ARA averaged €193/m³ from 1 February-1 December 2024. Biomethanol slows Lower ticket prices in the UK have kept a lid on demand for alternative waste-based gasoline blendstock biomethanol. The Argus cif UK biomethanol price averaged $1,089/t from 1 Jauary-1 December, compared with $1,229/t during the same period of 2023. The European Commission's proposal to exclude automatic certification of biomethane and biomethane-based fuels, if relying on gas that has been transported through grids outside the EU, continues to slow negotiations for 2025 imports of biomethanol of US origin into the EU. But demand for biomethanol and e-methanol could be supported by growing interest from the maritime sector as shipowners seek to reduce emissions after the EU's FuelEU maritime regulation comes into effect. Shipping giant Maersk has signed several letters of intent for the procurement of biomethanol and e-methanol from producers such as Equinor , Proman and OCI Global . By Evelina Lungu Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Business intelligence reports

Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.

Learn more