USGC bunker fuel producers not blending jet fuel

: Oil products
20/09/24

A historic plunge in aviation demand may have cut jet fuel prices low enough for blending into marine fuels on paper, but US Gulf coast refiners are wary of such a move, citing ship engine compatibility concerns and flash point and viscosity issues.

No Gulf coast refineries have been reported blending straight-run kerosene, typically processed into jet fuel, to produce low-sulphur fuel oil (LSFO), according to multiple market sources, despite reports of such practices in Singapore, the world's largest bunkering hub.

Gulf coast sources cited the challenges of the blending process. Too much straight-run kerosene has the potential to lower the temperature at which fuels ignite, known as the flash point, posing a dangerous risk to ship engines. Kerosene molecules are also shaped differently from the heavier fuel oil molecules, which means they resist staying in suspension. Too much light distillate could also create vapor lock issues on ships that run on fuel oil.

The relatively small scale of the bunker market in the US Gulf coast, compared to Singapore, also makes such a move not worth the associated risks, sources say. One market participant estimated a maximum of 40,000 bl of jet fuel components, or roughly 4,700 mt, could be blended into the monthly 4mn mt of LSFO demand in Singapore, where over a dozen very large crude carriers (VLCCs) of LSFO currently reside. In contrast, the Gulf coast market is a fraction of the Singapore market, with no floating LSFO VLCCs in the region.

Yet another hurdle is the still-low LSFO demand, despite a recent rise. LSFO demand in the US Gulf coast has remained relatively thin amid disruptions from Hurricane Laura and tropical storm Beta in the past few weeks. Low demand means blending straight-run kerosene — which increases a supplier's liability to shipowners — is too risky a move to take at this time, sources say.

Jet fuel is more likely being used in US Gulf coast refineries as cutterstock, a light petroleum stream blended to reduce viscosity. LSFO production requires blending lower-viscosity material with high-viscosity residual fuel oil to meet the minimum viscosity specification shipowners prefer for LSFO, which is usually no less than 30cst.

Inverted prices

Technical difficulties, safety and economic risks aside, low jet fuel prices and resurgent shipping demand have inverted the typical pricing relationship between jet fuel and LSFO, making such blending potentially viable on paper.

Jet fuel flipped to a discount to LSFO on 11 August this year, a discount that has widened steadily. Gulf coast Colonial pipeline jet fuel has averaged a $3.47/bl discount to US Gulf coast LSFO so far this month, widening from a $2.51/bl discount in August. A year earlier, jet fuel averaged a $9.14/bl premium to LSFO in September 2019.

The US Gulf coast shipping industry, on the other hand, has strengthened marginally as the US relieved lockdown measures in recent months related to the Covid-19 pandemic. LSFO steadily made gains alongside Ice Brent crude this month, reaching up to $50.08/bl on 1 September, the highest since 6 March. Prices have averaged $46/bl so far this month. LSFO's premium to Brent has also grown to an average $4/bl so far in September, up from $2.65/bl in August.

Part of LSFO's price strength comes from a shortage of vaccum gasoil (VGO), a main blending component for LSFO that does not carry the technical risks of jet fuel. VGO supplies have tightened as low margins cut crude throughput.

US Gulf coast fuel oil production fell to 34,000 b/d as of 18 September, marking the lowest level since 10 July, when levels dove into negative territory, and a 122,000 b/d dip from year-ago levels, according to data from the US Energy Information Administration (EIA).

By Kayla Meyertons and Wendy Dulaney

Related news posts

Argus illuminates the markets by putting a lens on the areas that matter most to you. The market news and commentary we publish reveals vital insights that enable you to make stronger, well-informed decisions. Explore a selection of news stories related to this one.

24/11/05

South Africa plans to upgrade Sapref to 600,000 b/d

Cape Town, 5 November (Argus) — The South African government plans to repair and expand the closed 180,000 b/d Sapref refinery in Durban, in the KwaZulu-Natal province, creating a facility with at least 600,000 b/d of capacity, according to the Central Energy Fund (CEF). State-owned CEF struck a deal in May to acquire Sapref from BP and Shell. The government wants to upgrade the refinery to ensure that South Africa has security of supply, CEF group chair Ayanda Noah told delegates at the Africa Energy Week underway in Cape Town. "Nowadays, a refining capacity of 600,000 b/d upwards is more economical, and that is what South Africa is aiming for," Noah said. "We are very ambitious." Sapref was South Africa's largest oil refinery with around 35pc of the country's refining capacity before it was shut in 2022 . That followed the closure of Engen's 105,000 b/d Durban refinery in 2020. Only three of South Africa's refineries remain operational — Astron Energy's 100,000 b/d Cape Town refinery, Sasol and TotalEnergies' 107,000 b/d Natref refinery and Sasol's 150,000 b/d coal-to-liquids plant at Secunda. South Africa now only has 35pc of its original refining capacity left, which means it has to import the balance, according to Noah. "You cannot outsource security of supply," she said. "There are many other variables that are outside our control. Look at the geopolitical tensions up north that affects supply chains negatively." Importing around 65pc of oil products is not efficient, especially given South Africa's high unemployment rate, Noah said. "Essentially, what we've done, is export downstream jobs." There is also a negative impact on the balance of payments and the economy, because South Africa cannot control prices, Noah added. It is the role of the CEF as a state-owned company to assist when there are market failures, she said. BP and Shell each owned a 50pc stake in the refinery and were looking to sell the facility after halting operations in 2022. But these plans were set back after extensive flood damage at the plant in April of that year, only two months after it was shut indefinitely. Four years ago, UK-based consultancy Citac estimated it would cost around $15.7bn to upgrade all of Africa's refineries to Afri-6 clean fuel standards, its chief executive Gary Still said in an interview. But those calculations were made before Sudan's 100,000 b/d Khartoum refinery was shut and Ghana's 120,000 b/d Sentuo refinery came online, Still said. It is also likely that the cost of refinery upgrades has increased substantially as goods and services became more expensive after the Covid-19 pandemic, while engineering firms and personnel with the necessary expertise are less available, Still said. By 2030, the African Refiners and Distributors Association (ARDA) wants African countries to meet Afri-6, which imposes a 10ppm sulphur limit on gasoline and diesel, in line with Euro 5 fuel specifications. ARDA's executive secretary Anibor Kragha, described the Sapref acquisition as "phenomenal," because South Africa is "claiming its energy independence through it," he said. By Elaine Mills Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Phillips 66 Calif shutdown to shift tanker flows

24/11/05

Phillips 66 Calif shutdown to shift tanker flows

Houston, 5 November (Argus) — Phillips 66's plans for a late 2025 shutdown of its 139,000 b/d refinery in Los Angeles, California, will likely lead to more trans-Pacific refined products tanker shipments into the US west coast while having a more muted effect on crude tankers. Phillips 66 said it would likely shut the refinery in the fourth quarter of 2025, citing the high regulatory costs of operating in California. While it is unclear what will become of the facility, Phillips 66 said it still plans to supply the region with road fuels in the future. The closure will reduce California's refining capacity by 8.6pc to about 1.48mn b/d and removes about 14pc of refining capacity in the Los Angeles area. Tankers hauled about 160,000 b/d of refined products to California in January-October, with about 95,000 b/d going to Los Angeles, according to data from analytics firm Vortexa. About 27pc of the deliveries to Los Angeles came from refiners on the US Gulf coast and elsewhere on the US west coast on Jones Act-compliant vessels, which must be US-built, US-flagged and US-crewed. But the relatively small Jones Act fleet is already fully utilized, with no additional ships on order, shipbroker Poten said. This means replacement supplies of refined products will need to come from farther afield, likely Asia-Pacific. South Korea is Los Angeles' biggest source of waterborne refined products so far this year, shipping about 33,000 b/d in January-October, Vortexa data show, followed by other US sources (25,000 b/d), China (9,000 b/d), India (9,000 b/d) and Canada (8,500 b/d). Taiwan, Singapore and Japan also have supplied marginal cargoes to Los Angeles this year. An increase of California-bound shipments from these countries would create additional demand for voyages lasting a range of 19-35 days, boosting ton-mile demand and tanker employment in the Pacific basin. Medium range (MR) and long range 1 (LR1) refined product tankers would benefit the most from these increased trade flows, with MRs accounting for 67pc of the current market share and LR1s 33pc, according to Vortexa data. Tanker demand for exports from the US west coast is unlikely to be affected. Phillips 66 Los Angeles exported just 2,000-4,000 b/d of products in January-October, data from Kpler and Vortexa show. Limited impact on crude tankers Because Phillips 66's Los Angeles refinery was designed to process domestic California crude, the impact on the regional crude tanker market likely will be much more limited — and offset by increased tanker demand on Canada's Pacific coast. With available domestic — albeit declining — California crude production, the 139,000 b/d refinery imported 64,000 b/d of crude in January-August 2024, mostly from short-haul sources in the Americas, the latest data from the US Energy Information Administration (EIA) show. The trade was dominated by 1mn bl Suezmaxes and 500,000-700,000 bl Aframaxes. The refinery imported 15.52mn bl of crude in January-August 2024, according to the EIA. Canada was the largest international supplier (4.84mn bl) in that span, boosted by the Trans Mountain Expansion (TMX) pipeline start-up in May, followed by Guyana (3.48mn bl) via the Trans-Panama Pipeline, Mexico (2.98mn bl), Brazil (2.92mn bl) and Ecuador (1.3mn bl). Because of the refinery's use of domestic crude supplies, the complex's imports are equivalent to just two Suezmax shipments or three Aframax shipments per month. For the regional tanker market, that is more than offset by the burgeoning TMX flows on Canada's Pacific coast, which in October loaded a record 24 Aframaxes , destined to refineries in China and the US west coast. By Tray Swanson Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

EU contributed $31.2bn public climate finance in 2024

24/11/05

EU contributed $31.2bn public climate finance in 2024

Edinburgh, 5 November (Argus) — The EU has contributed €28.6bn ($31.2bn) in climate finance from public sources in 2024 to help developing countries cut their greenhouse gas emissions (GHG) and adapt to climate change, according to the European Council. Around half the funding went to climate adaptation or to cross-cutting action, which involves both mitigation — reducing GHG emissions — and adaptation. Almost 50pc took the form of grants, according to the EU. The €28.6bn includes €3.2bn from the EU budget, including from the European Fund for Sustainable Development Plus, and €2.6bn from the European Investment Bank. The EU said it also mobilised €7.2bn of private finance last year, and it "seeks to extend the range and impact of sources and financial instruments and to mobilise more private finance". The figures were released ahead of the UN Cop 29 climate talks, which open on 11 November in Baku, Azerbaijan. Finance will be a key topic at this year's summit as parties to the Paris deal will seek to agree on a new finance goal for developing nations, following on from the current, but broadly recognised as inadequate, $100bn/yr target. EU negotiators have signalled willingness to support "a stretched goal" with a public finance core, but have yet to provide a figure. Developed countries in general have yet to commit to a number for climate finance, while developing nations have for some time called for a floor of at least $1 trillion/yr. By Caroline Varin Europe's contribution to climate finance €bn Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

US railroad-labor contract talks heat up

24/11/04

US railroad-labor contract talks heat up

Washington, 4 November (Argus) — Negotiations to amend US rail labor contracts are becoming increasingly complicated as railroads split on negotiating tactics, potentially stalling operations at some carriers. The multiple negotiating pathways are reigniting fears of 2022, when some unions agreed to new contracts and others were on the verge of striking before President Joe Biden ordered them back to work . Shippers feared freight delays if strikes occurred. This round, two railroads are independently negotiating with unions. Most of the Class I railroads have traditionally used the National Carriers' Conference Committee to jointly negotiate contracts with the nation's largest labor unions. Eastern railroad CSX has already reached agreements with labor unions representing 17 job categories, which combined represent nearly 60pc of its unionized workforce. "This is the right approach for CSX," chief executive Joe Hinrichs said last month. Getting the national agreements on wages and benefits done will then let CSX work with employees on efficiency, safety and other issues, he said. Western carrier Union Pacific is taking a similar path. "We look forward to negotiating a deal that improves operating efficiency, helps provide the service we sold to our customers" and enables the railroad to thrive, it said. Some talks may be tough. The Brotherhood of Locomotive Engineers and Trainmen (BLET) and Union Pacific are in court over their most recent agreement. But BLET is meeting with Union Pacific chief executive Jim Vena next week, and with CSX officials the following week. Traditional group negotiation is also proceeding. BNSF, Norfolk Southern and the US arm of Canadian National last week initiated talks under the National Carriers' Conference Committee to amend existing contracts with 12 unions. Under the Railway Labor Act, rail labor contracts do not expire, a regulation designed to keep freight moving. But if railroads and unions again go months without reaching agreements, freight movements will again be at risk. By Abby Caplan Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Canada advances oil and gas GHG cap

24/11/04

Canada advances oil and gas GHG cap

Houston, 4 November (Argus) — Canada is proposing to use a cap-and-trade system to reduce greenhouse gas (GHG) emissions from its oil and gas sector, a long-promised but politically contentious move. The proposed program aims to reduce emissions from the sector by 35pc, compared to 2019 levels, by 2030-32, according to a draft rule published by Environment and Climate Change Canada (ECCC) on Monday. It would cover upstream production activities, both onshore and offshore, including for oil, natural gas and liquified natural gas. After an initial four-year phase-in over 2026-29, entities would then need to meet their emissions obligations over the first 2030-2032 compliance period. While all operators must report emissions, only those producing more than 365,000 b/yr of oil equivalent, equal roughly to 99pc of upstream emissions, would be covered by the trading program. Covered entities would receive free allowance allocations, which would decline in line with their emissions cap. Companies could also buy allowances on the secondary market if needed, use carbon offsets or contribute funds to a decarbonization program. The first three-year compliance period of 2030-31, would be set at 27pc below emissions reported for 2026, which ECCC said would be equivalent to the 35pc target. The federal program will not link with the California-Quebec joint carbon market, known as the Western Climate Initiative, regulators said. ECCC officials stressed that the resulting program would cap emissions, not production, for Canadian oil producers, pushing back at a common criticism from opponents. The federal move will keep the industry accountable to its own promise of net-zero by 2050 and result in a greener and more competitive industry, said Canada Natural Resources Minister Jonathan Wilkinson. "As the world moves to reduce emissions generated by the production and combustion of fossil fuels, oil and gas extracted with the lowest production of emissions will have value in the world," Wilkinson said. But Alberta premier Danielle Smith claimed on Monday that the proposed program violates Canada's constitution. Provinces have exclusive authority over non-renewable natural resource development and the proposal ignores ongoing projects in the province, such as the Pathways Alliance, she said. Canadian Natural Resources, Cenovus, ConocoPhillips Canada, Imperial, MEG Energy and Suncor Energy are involved in the project. The program is a cap on production and will cost the province "anywhere from C$3bn-$7bn ($2.1-5bn)/yr" in absent royalty payments because of a loss of 1mn b/d in production, Smith said, promising future legal challenges against the federal government. "The only way to achieve these unrealistic targets is to shut in our production, I know it, they know it. We are calling them out on it, and they have to stop it," she said. Canada, a major net exporter of oil, has committed to reducing emissions by 40-45pc, compared to 2005 levels, by 2030 and net-zero by 2050. But emissions from the country's oil and gas sector remain an obstacle to meeting those goals. The sector accounts for 31pc, or 217mn metric tonnes, of the country's emissions in 2022 , according to the most recent federal data. Emissions from this sector increased by 83pc from 1990 to 2022. Over the past year Canada's federal government has focused on competitive climate change-related policies, from rolling out investment tax credits for decarbonization technologies to enforcement of the government's new Clean Fuel Regulations. But the road for the Liberal Party-led government to meet the climate goals remains a rocky one ahead of a federal election that must take place no later than October 2025. In September, the Conservative Party, led by Pierre Poilievre, attempted a no confidence measure on prime minister Justin Trudeau's government, fed by discontent around the federal carbon tax. While the motion failed, it highlights the balancing act for the Liberal Party ahead of the election. Trudeau has resisted calls from within his party to cede the field as his popularity waned, to the benefit of Poilievre. ECCC plans to request public comment on the proposal through 8 January 2025 and estimates it will finalize the regulations next year. By Denise Cathey Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.

Business intelligence reports

Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.

Learn more