Shell, BlueScope work on Australian hydrogen hub

Market: Hydrogen, Metals
07/12/21

Australia-based steel producer BlueScope Steel has agreed to work with Shell to develop a renewable hydrogen hub at its 2.1mn t/yr Port Kembla steelworks in the Illawarra region of New South Wales (NSW).

The two firms will initially investigate building a 10MW pilot-scale renewable hydrogen electrolyser to allow them to test the use of green hydrogen in BlueScope's blast furnace at Port Kembla. The hydrogen could also be used to feed a pilot direct reduced iron (DRI) plant at Port Kembla, as part of BlueScope's tie-up with UK-Australian mining firm Rio Tinto to investigate green steel production.

BlueScope and Shell will also look to collaborate with other organisations to develop a hydrogen hub in the Illawarra region. The NSW government has created an A$3bn ($2.2bn) state-funded investment plan to develop green hydrogen hubs in the Illawarra and Hunter Valley regions of the state. Both regions are coal mining centers and Shell and BlueScope will look at options to supply both electricity and hydrogen to local manufacturing and mining industries.

"Any future potential hydrogen hub in the Illawarra will need broad support from governments, regulators, customers and suppliers," BlueScope chief executive Mark Vassella said.

BlueScope has committed to invest A$150mn into reducing its greenhouse gas (GHG) emissions over the next five years. But it is also moving forward with the A$700mn-800mn reline of its blast furnace at Port Kembla, which implies a 20-year commitment to traditional steelmaking using iron ore and coking coal, albeit with some tweaks to minimise emissions.

It plans to initially replace pulverised coal injection (PCI) grade coking coal with gas from its coke ovens, which contain 60pc hydrogen. It has also teamed up with the federal government's Commonwealth Scientific and Industrial Research Organisation (CSIRO) to work on the pilot hydrogen electrolyser at Port Kembla to supplement coke oven gas.

BlueScope is also partnering with CSIRO to use charcoal produced from the pyrolysis of organic material, or biochar, as another replacement for a portion of the metallurgical coal used in the blast furnace. This, combined with the increased use of scrap and renewable power sources, is part of the firm's plan to begin reducing its carbon emissions in the short term.

BlueScope has set a goal of net-zero GHG emissions by 2050. It was unable to set the more ambitious target of net-zero emissions by 2030 because the technology to do so is not yet commercially viable, according to Vassella.

By Jo Clarke

Related news posts

Argus illuminates the markets by putting a lens on the areas that matter most to you. The market news and commentary we publish reveals vital insights that enable you to make stronger, well-informed decisions. Explore a selection of news stories related to this one.

News

02/05/25

Exxon sees 45V surviving, needs blue H2 offtake

Houston, 2 May (Argus) — ExxonMobil chief executive officer Darren Woods expects low-carbon hydrogen production incentives to survive a White House review, but he wants more sales commitments before making a final investment decision on a company project in Baytown, Texas. "Our expectation is that things that we need to drive low-carbon hydrogen will probably stay in place," Woods said during the company's first-quarter earnings call Friday. "But we have to see that manifested." Woods has said that the 45V hydrogen production tax credit is "critical" to establishing a market for the zero-emissions fuel that can stand on its own and compete against fossil fuels. The company is developing what it describes as the largest low-carbon hydrogen plant in the world in Baytown, designed to produce 1bn cf/d of hydrogen from natural gas with carbon capture. While the 45Q incentive is available for projects using carbon capture and sequestration to lower emissions, ExxonMobil has repeatedly indicated it is pursuing the more lucrative 45V for the massive hydrogen and ammonia production project planned on the Texas Gulf coast. In addition to certainty about federal incentives, Woods said the company also needs to secure more offtake agreements in order to make a final investment decision. "I'd say right now that's probably the long pole in the tent with respect to driving this," Woods said. "When those two things come together and we're confident that we have what we need to generate the returns that's going to be required to justify the investments, we'll move forward. Hopefully, that's later this year." Most of the project's production would be used to decarbonize operations at Exxon's 564,500 b/d Baytown refinery, while the remainder is being targeted for exports in the form of ammonia. In January, the company signed an agreement to sell ammonia to European trading firm Trammo. Japanese power producer Jera has said it is considering 500,000 t/yr of ammonia offtake as part of its plans to take an equity stake in the project. By Jasmina Kelemen Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Find out more

News

Cliffs to idle 3 US steel mills this summer

02/05/25

News

02/05/25

Cliffs to idle 3 US steel mills this summer

Houston, 2 May (Argus) — Integrated steelmaker Cleveland-Cliffs will indefinitely idle its Conshohocken, Riverdale, and Steelton steel mills this summer in response to weak demand for the products produced at the mills. The idlings will impact about 950 workers spread across the 700,000 short ton (st)/yr Riverdale high-carbon coil mill in Illinois, the 500,000st/yr Conshohocken specialty plate mill in Pennsylvania and the 300,000st/yr Steelton, Pennsylvania railroad rail mill, a company spokesperson told Argus . Cliffs said the moves are temporary and will begin at the end of the required 60-day WARN notice periods in their respective states — on or about 30 June. By Marialuisa Rincon Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

News

US adds 177,000 jobs in April, jobless rate steady

02/05/25

News

02/05/25

US adds 177,000 jobs in April, jobless rate steady

Houston, 2 May (Argus) — The US added 177,000 jobs in April, topping expectations, even as the new US administration's campaign of tariffs against allies and trading partners heightened business and consumer uncertainty. Economists surveyed by Trading Economics had forecast job gains of 130,000 for April. The unemployment rate held steady at 4.2pc in April, the Bureau of Labor Statistics (BLS) reported. Job gains for March were revised lower by 43,000 to 185,000. The unexpectedly strong job report comes two days after the government reported the economy contracted at a 0.3pc annual rate in the first quarter, largely on a surge in imports as companies sought to build inventory ahead of the impacts of President Donald Trump's import tariffs. Consumer and business confidence have tumbled and economists have raised the odds of a US recession this year. US job gains averaged 152,000 in the 12 months prior to April. Federal government employment declined by 9,000 jobs in April and has fallen by 26,000 since January as mass federal layoffs take effect. Employees on paid leave or receiving severance pay are counted as employed, BLS said, so most of the announced federal job cuts do not yet show up in the data. Health care added 51,000 jobs in April, while transportation and warehousing added 29,000 jobs, more than double the average in the prior 12 months. Financial activities added 14,000 jobs. Construction added 11,000 jobs and manufacturing lost 1,000 jobs. Leisure and hospitality jobs grew by 24,000 and health care and social assistance added 78,000 jobs. Average hourly earnings rose by a 3.8pc annual rate, unchanged from the pace in March. By Bob Willis Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

News

South Australia closes Hydrogen Power SA office

02/05/25

News

02/05/25

South Australia closes Hydrogen Power SA office

Sydney, 2 May (Argus) — The state government of South Australia has rolled its Office of Hydrogen Power SA (OHPSA) into the Department of Energy and Mining (DEM), after scrapping plans for a 250MW electrolyser and 200MW hydrogen-fired power station. The OHPSA has been absorbed into the other state department, a spokesperson for SA energy minister Tom Koutsantonis said on 2 May. This comes after the state cut the A$593mn ($381mn) it had promised for its Hydrogen Jobs Plan in early 2025. The funds were reallocated to subsidise the 1.2mn t/yr Whyalla steelworks, which entered administration on 19 February . The associated Office of Northern Water Delivery, which was intended to support the green hydrogen sector in the state's upper Spencer Gulf region with new water pipeline supply, has also been incorporated within the DEM, Koutsantonis said on 1 May. SA's other major hydrogen hub planned at nearby Port Bonython was also overseen by the OHPSA. Development agreements with five companies have been signed for Port Bonython, including with London-based energy company Zero Petroleum for an e-SAF plant . SA is aiming to transition the ageing Whyalla steelworks to develop low emissions iron and steel products, but administrator KordaMentha is yet to finalise a buyer for Whyalla's controlling company OneSteel, which was formerly owned by UK-based GFG Alliance. By Tom Major Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

News

Australia's Coalition eyes power, resource funding cuts

02/05/25

News

02/05/25

Australia's Coalition eyes power, resource funding cuts

Sydney, 2 May (Argus) — Australia's federal Coalition opposition has announced it will cut key energy rebates and resource sector subsidies, if elected on 3 May, to reduce forecast future budget deficits. The Peter Dutton-led opposition will cut programs, including the Labor government's A$20bn ($12.8bn) Rewiring the Nation transmission plan, and the A$15bn National Reconstruction Fund aimed at underwriting green manufacturing using domestic minerals. It will also unwind electric vehicle tax concessions to save A$3.2bn, and cancel planned production tax credits for critical minerals processing and green hydrogen estimated to cost A$14.7bn. Combined savings measures will improve the budget's position by A$13.9bn over the four years to 2028-29, the Coalition said on 1 May, cutting debt by A$40bn during the same timeframe. The announcement comes as opinion polls show Australia's next federal government is likely to force one of the two major parties into minority, after a campaign where cost-of-living relief promises have trumped economic reform policy. The centre-left Labor party is more likely than the conservative Coalition to form government at the 3 May poll. It holds a thin majority of just three seats in parliament's main chamber, the House of Representatives, meaning a swing against it would force it to deal with minor parties such as the Greens and independent groupings. Promising a stable government, as Australia emerged from Covid-19, Labor had benefited from a resources boom as Russia's invasion of Ukraine led LNG and coal receipts to skyrocket and China's emergence from lockdowns revitalised its demand for iron ore, which jointly form the nation's main commodity exports. But as markets adjust to a period of protectionist trade policy and predictions of a slowdown in global growth abound, economists have criticised the major parties' reluctance to embrace major reform on areas such as taxation, while continuing to spend at elevated levels post-pandemic. Australia's resource and energy commodity exports are forecast to fall to A$387bn in the fiscal year to 30 June 2025 from A$415bn in 2023–24. The Office of the Chief Economist is predicting further falls over the next five years, reaching A$343bn in 2029-30, lowering expected government revenue from company tax and royalties. Gas The Coalition has pledged a domestic reservation scheme for the east coast, forcing 50-100PJ (1.34bn-2.68bn m³/yr) into the grid by penalising spot LNG cargoes. Australia's upstream lobby has opposed this, but rapidly declining reserves offshore Victoria state mean gas may need to be imported to the nation's south, depending on the success of electrification efforts and an uncertain timeline for coal-fired power retirements. Labor has resisted such further gas interventions , but it is unclear how it will reverse a trend of rising gas prices and diminishing domestic supply, despite releasing a future gas plan last year. The party is promising 82pc renewables nationally by 2030, meaning it will have to nearly double the 2025 year-to-date figure of 42pc. This could require 15GW of gas-fired capacity by 2050 to firm the grid. On environmental policy, narrowing polls mean Labor's likely partners in government could be the anti-fossil fuel Greens and climate-focused independents — just some of the present crossbench of 16 out of a parliament of 151. The crossbench may drive a climate trigger requirement in any changes to environmental assessments, which could rule out new or brownfield coal and gas projects. Coal has been conspicuously absent from policy debates, but Labor has criticised the Coalition's nuclear energy policy as expensive and unproven, while the Coalition has said Labor's renewables-led grid would be unstable and costly because of new transmission requirements. The impact of the US tariff shock that dominated opening days of the month-long election campaign remains unclear. Unlike Canada, Australia is yet to be directly targeted by US president Trump's rhetoric on trade balances and barriers. But the global unease that has set in could assist Labor's prime minister Anthony Albanese, as he presents an image of continuity in an uncertain world economy. Australia's main exposure to Trump tariffs is via China, its largest trading partner and destination for about 35pc of exports, including metal concentrates, ores, coal and LNG. A downturn in the world's largest manufacturer would spell difficult times ahead for Australia, as it grapples with balancing its budget in a normalising commodity market. By Tom Major Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Business intelligence reports

Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.

Learn more