Scrubber fitting times up 33pc in 3Q: Clarksons

Market: Oil products
18/10/19

Ships fitted with exhaust gas cleaning systems in September spent an average of 44 days out of service, a 33pc increase from 33 days for installation of such scrubber systems in June, according to shipping firm Clarksons.

Shipyards have become increasingly congested with demand for scrubber installations in vessels before January 2020, when the International Maritime Organisation's sulphur cap on marine fuel emissions comes into effect.

The majority of these installations are retrofits, in which an active vessel is sent to a shipyard for a new installation. Of those retrofits 80pc are done in Chinese shipyards.

Clarksons says 15pc of crude tankers, measured by tonnage capacity, are projected to be fitted with scrubbers by the end of 2019. This includes 25pc of the global fleet of Very Large Crude Carriers (VLCCs), which carry 2mn barrel cargoes, and 18pc of Suezmax vessels, which carry 1mn barrel cargoes. By the end of 2020, this figure will increase to 21pc of all crude tankers, 34pc of VLCCs and 26pc of Suezmaxes.

Scrubber uptake levels have been marginally lower for dry bulk carriers. Of the global fleet of dry bulk carriers 13pc will be fitted with scrubbers by the end of 2019, including 26pc of Capesize vessels, which carry around 180,000t cargoes. By the end of 2020 Clarksons estimates 18pc of the global dry bulk carrier fleet will be fitted with scrubbers, including 36pc of Capesizes.

Retrofitting scrubbers reduced the supply of active vessels in the freight market, with Clarksons' research showing that more than 2pc of crude tankers were taken out of service in September this year for scrubber installations.

Ships with scrubbers will be able to use 3.5pc sulphur fuels and still comply with IMO 2020 regulations, which are expected to be much cheaper than low-sulphur fuel alternatives such as LNG, marine gas oil and 0.5pc fuel next year.

The number of scrubber-fitted vessels has increased ten-fold in the past two years, from an estimated 400 vessels at the start of 2018 to 4,000 at the start of 2020. Clarksons projects that this will increase to 19pc of the global fleet by the end of 2020.

Related news posts

Argus illuminates the markets by putting a lens on the areas that matter most to you. The market news and commentary we publish reveals vital insights that enable you to make stronger, well-informed decisions. Explore a selection of news stories related to this one.

News

01/05/25

US bill would extend expired biofuel credits

New York, 1 May (Argus) — Legislation soon to be introduced in the US House would extend expired biofuel incentives through 2026, potentially providing a reprieve to refiners that have curbed production this year because of policy uncertainty. The bill, which will be sponsored by US representative Mike Carey (R-Ohio) and some other Republicans on the powerful House Ways and Means Committee, according to a person familiar, could be introduced as soon as today. It would prolong both the long-running $1/USG for blenders of biomass-based diesel and a separate incentive that offers up to $1.01/USG for producers of cellulosic ethanol. The credits expired at the end of last year but under the proposal would be extended through both 2025 and 2026. The incentives would run alongside the Inflation Reduction Act's new "45Z" credit for clean fuel producers, which offers a sliding scale of benefits based on carbon intensity, though the bill would prevent double claiming of credits, according to bill text shared with Argus . The 45Z credit is less generous across the board to road fuels — offering $1/USG only for carbon-neutral fuels and much less for crop-based diesels — and is still in need of final rules after President Joe Biden's administration issued only preliminary guidance around qualifying. The proposal then would effectively offer a more generous alternative through 2026 for biodiesel, renewable diesel, and cellulosic ethanol but not for other fuels that can claim the technology-neutral 45Z incentive. That could upend the economics of renewable fuel production. Vegetable oil-based diesels for instance could claim the blenders credit and earn more than aviation fuels that draw from the same feedstocks. According to Argus Consulting estimates, aviation fuels derived from wastes like distillers corn oil and domestic used cooking should still earn more than $1/USG this year, conversely, since 45Z is more generous to aviation fuels. Extending the biodiesel blenders credit would also allow foreign fuel imports to again claim federal subsidies, a boost for Finnish refiner Neste and the ailing Canadian biofuel startup Braya Renewable Fuels but a controversial provision for US refiners and feedstock suppliers. The 45Z incentive can only be claimed by US producers. The blenders incentive is also popular among fuel marketer groups, which have warned that shifting subsidies to producers could up fuel costs. The proposal adds to a contentious debate taking place across the biofuel value chain about what the future of clean fuel incentives should look like. Some industry groups see a wholesale reversion to preexisting biofuel credits — or even a temporary period where various partly overlapping incentives coexist — as a tough sell to cost-concerned lawmakers and have instead pushed for revamping 45Z. A proposal last month backed by some farm groups would keep the 45Z incentive but ban foreign feedstocks and adjust carbon intensity modeling to benefit crops. Republicans could keep, modify, extend, or repeal the 45Z incentive as part of negotiations around a larger tax bill this year. But the caucus is still negotiating how much to reduce the federal budget deficit and what to do with Inflation Reduction Act incentives that have spurred clean energy projects in conservative districts. Uncertainty about the future of biofuel policy and sharply lower margins to start 2025 have led to a recently pronounced drop in biodiesel and renewable diesel production . President Donald Trump's administration is working on new biofuel blend mandates, which could be proposed in the coming weeks, but has said little about its plans for biofuel tax policy. By Cole Martin Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Find out more

News

Brazil's energy transition spending drops in 2024

30/04/25

News

30/04/25

Brazil's energy transition spending drops in 2024

Sao Paulo, 30 April (Argus) — Brazil's mines and energy ministry's (MME) energy transition spending shrank by 83pc in 2024 from the prior year, while resources for fossil fuel incentives remained unchanged, according to the institute of socioeconomic studies Inesc. The MME's energy transition budget was R141,413 ($24,980) in 2024, down from R835,237 in the year prior. MME had only two energy transition-oriented projects under its umbrella last year: biofuels industry studies and renewable power incentives, which represented a combined 0.002pc of its total R7bn budget. Still, despite available resources, MME did not approve any projects for renewable power incentives. It also only used 50pc of its budget for biofuel studies, Inesc said. Even as supply from non-conventional power sources advances , most spending in Brazil's grid revamp — including enhancements to better integrate solar and wind generation — comes from charges paid by consumers through power tariffs, Inesc said. Diverging energy spending Brazil's federal government also cut its energy transition budget for 2025 by 17pc from last year and created a new energy transition program that also pushes for increased fossil fuel usage. The country's energy transition budget for 2025 is R3.64bn, down from R4.44bn in 2024. The new program — also under MME's umbrella — has a budget of around R10mn, with more than half of it destined to studies related to the oil and natural gas industry, Inesc said. A second MME program — which invests in studies in the oil, natural gas, products and biofuels sectors — has an approved budget of R53.1mn. The science and technology ministry is the only in Brazil that increased its energy transition spending for 2025, with R3.03bn approved, a near threefold hike from R800mn in 2024. Spending will focus on the domestic industry sector's energy transition, Inesc said. Despite hosting the UN Cop 30 summit in November, Brazil has constantly neglected to address the phase-out of fossil fuels, drawing the ire of climate activists . By Maria Frazatto Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

News

Mexican economy grows 0.6pc in 1Q

30/04/25

News

30/04/25

Mexican economy grows 0.6pc in 1Q

Mexico City, 30 April (Argus) — Mexico's economy expanded at an annualized rate of 0.6pc in the first quarter, with solid growth in the agriculture sector offsetting a slowdown in industry. The result came in at the high end of analyst estimates and slightly above the 0.5pc GDP growth reported by statistics agency Inegi for the fourth quarter of 2024. Still, it marks the second-slowest quarterly growth in the past 16 quarters. Most of the first quarter's GDP growth came from a 6pc expansion in the agricultural sector, which more than reversed the 4.6pc contraction recorded in the fourth quarter of 2024. The industrial sector — including mining, manufacturing and construction — shrank for a second straight quarter, contracting by 1.4pc after a 1.2pc drop in the previous quarter. Manufacturing faced tariff-related uncertainty during the quarter, though investment in the sector had already been slowing for months. The contraction was softened by manufacturers ramping up production ahead of US tariffs, with the risk of trade-driven inflation also pushing builders to contain construction costs, according to market sources. These effects are expected to fade in the second quarter and worsen in the third if high US tariffs on Mexican goods persist, said Victor Herrera, head of economic studies at finance executive association IMEF, "especially as supply chains are hit by dwindling inventories." Services expanded by an annualized 1.3pc in the first quarter, compared with a 2.1pc growth in the fourth quarter of 2024. This marks the slowest growth in services since the end of Covid-19 restrictions in early 2021. By James Young Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

News

Repsol sees Spanish refineries back to normal in a week

30/04/25

News

30/04/25

Repsol sees Spanish refineries back to normal in a week

Adds chief executive's comments and further detail on refineries Madrid, 30 April (Argus) — Repsol said it expects its five Spanish refineries to return to normal operations within a week following the nationwide power outage on Monday, 28 April. The company confirmed that power was restored to all its refineries on Monday evening, allowing the restart process to begin. It will take three days to restart the crude distillation units and 5-7 days to restart secondary conversion units, with hydrocrackers taking the longest, according to chief executive Josu Jon Imaz. A momentary and unexplained drop in power supply on the Spanish electricity grid caused power cuts across most of Spain and Portugal, disrupting petrochemical plants and airports, as well as refineries. Imaz noted that Repsol was fortunate that its refineries avoided damage from petroleum coke formation and other solidification processes during the shutdown. Repsol's 220,000 b/d Petronor refinery in Bilbao was the first to restart, thanks to electricity imports from France, he said. Petroleum reserves corporation Cores has temporarily reduced Spain's obligation to hold 92 days of oil product consumption as strategic reserves by four days, mitigating potential supply issues from the outage. Repsol's refining margin indicator, a benchmark based on European crack spreads weighted to the firm's product basket, has been recovering this week and stood at $7.5/bl this morning, compared with an average of $4.2/bl in April and $5.3/bl in the first quarter, according to Imaz. The company posted a 70¢/bl premium to the indicator in January-March on refinery optimisation and use of heavier and cheaper crudes. This was lower than the $1.20/bl premium it reported in 2024 and negatively affected by the high water content in first-quarter deliveries of heavy Mexican Maya, a staple for Repsol's more complex refineries. The high water cut in the Maya receipts shaved a potential 50¢/bl from Repsol's refining margin premium in the first quarter, and operational issues at the company's Tarragona refinery a further 20¢/bl, according to Imaz. Repsol has already completed the three major refinery maintenance projects for 2025 it flagged at its Bilbao, Tarragona and Puertollano refineries . Work on the three refineries in the first quarter cut about 40¢/bl from the firm's refining margin. The three factors point to a combined $1.10/bl shortfall in the firm's refining margin in the first quarter and were one of the reasons for the 80pc fall in adjusted profit at Repsol's refining-focused industrial division to €131mn ($149mn) in January-March from a year earlier and the 62pc fall in group profit to €366mn. By Jonathan Gleave Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

News

US sanctions weigh on Serbian refiner's sales

30/04/25

News

30/04/25

US sanctions weigh on Serbian refiner's sales

Budapest, 30 April (Argus) — Serbia's Russian-controlled refiner NIS faced challenges selling oil products to some of its customers in the first quarter due to US sanctions, the company said today. Runs at its 96,000 b/d Pancevo refinery rose despite these difficulties, albeit from a relatively low level a year earlier. The US announced sanctions against NIS in January because of its Russian ownership, but implementation has been postponed several times, most recently until 27 June . Even so, the threat of sanctions led NIS to reduce output at Pancevo as many customers suspended purchases, a source told Argus last month. NIS reported a 4pc year-on-year decline in oil product sales to 719,000t in January-March. Domestic wholesale and retail sales volumes fell by 16pc and 7pc to 246,000t and 203,000t, respectively. Foreign retail market sales decreased by 9pc to 34,000t, and overall motor fuel sales dropped by 8pc to 544,000t. Sales volumes fell partly because some customers terminated their contracts with NIS due to the US sanctions, the company said. Bunkering sales dropped by 25pc on the year because of difficulties in doing business with foreign clients as a result of the US restrictions, it added, without giving details. The negative effects were partially offset by a 75pc year-on-year increase in bitumen and coke turnover and a 3pc rise in jet fuel sales, NIS said, without giving volumes. Sales "through the export channel" were up by 73pc from a year earlier. NIS said it was operating in an "unstable" environment in January-March because of its "exposure to the US sanctions regime". Despite this, Pancevo increased runs of crude and semi-finished products by a third to 853,000t combined in the first quarter, although throughput was relatively low a year earlier due to a scheduled turnaround. The company said it is continuously adjusting Pancevo's slate of imported crude, based on spot market movements and procurement opportunities. NIS announced a tender to supply 2.15mn t of crude for Pancevo in April-December 2025 but cancelled the call earlier this year. By Bela Fincziczki Send comments and request more information at feedback@argusmedia.com Copyright © 2025. Argus Media group . All rights reserved.

Business intelligence reports

Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.

Learn more