Pilot fears rail crisis will cut US DEF, biofuel supply
Refined products retailer Pilot Travel Centers fears a move to cut rail traffic by western US railroad Union Pacific (UP) will drive a shortage of diesel exhaust fluid (DEF) and ethanol in the US.
UP this month ordered Pilot to cut rail shipments by 50pc or face embargoes on shipments of DEF — an important solution used to cut NOx emissions from diesel engines without hurting fuel efficiency — as well as ethanol, biodiesel and renewable diesel, Pilot chief executive Shameek Konar told the US Surface Transportation Board (STB) yesterday .
UP's "restrictions will prevent Pilot from keeping many markets adequately supplied with DEF, likely causing shortages that will sideline trucks and reduce trucking capacity," Konar said on the second of STB's two-day hearing on the rail service crisis.
Pilot has not cut volumes so far but UP also hasn't implemented an embargo. But Konar said he worries about the effect on Pilot and the trucking industry.
UP this month told some of its largest shippers that it will start limiting their rail volume if the carrier is unable to clear railcar congestion from its system.
UP told Pilot one day this month it had shipped about 160 cars during the prior week and wanted the shipper to reduce that by about 46 cars/week, or 6 cars/day.
"We have not reduced the cars because we would be in deep trouble," he said, adding that UP has not responded. Each railcar of DEF translates to about 5mn miles of trucking.
"If you lose 100mn USG of DEF, it would be absolutely catastrophic because we do not just supply ourselves," Konar said. He estimated the cuts would equate to removing 10pc of the trucks on the road today.
Pilot estimates it supplies 30pc of the DEF in the US. The company provides more than 300mn USG of DEF to the trucking industry annually, with about 74pc of that shipped by rail. Pilot also provides roughly 20pc of the nation's highway diesel, renewable diesel and biodiesel.
Cutting Pilot's renewable diesel volume, with about 50pc being shipped by rail, would increase fuel prices in certain states and potentially dry up supply, he said.
Cutting ethanol shipments from Pilot's plant in Nebraska to Arizona, Nevada and a few other regions is also expected to remove the amount of ethanol available to blend with gasoline, potentially raising prices.
Related news posts
Low Argentina rivers lift Brazil biodiesel
Low Argentina rivers lift Brazil biodiesel
Sao Paulo, 26 September (Argus) — A drop in river levels in Argentina's Parana upriver region amid a historical drought has snarled transport and inflated soybean oil and biodiesel prices in Brazil. The depth of the Parana River in Argentina's San Lorenzo city, a major hub for soybean oil shipments, dropped to 9.44m (30ft) on 20 September, the lowest level since January 2023, according to information provided by maritime agencies T&T and Antares. The lower river flow is forcing soybean oil traders to reduce how much product they load onto tankers that stop at Argentinian ports by between 5-12.5pc, according to Argentina market sources. A 12.5pc capacity reduction on a standard tanker would mean a loading 28,000 metric tonnes (t) instead of 32,000t. These restrictions have affected the Brazilian soybean oil and biodiesel market, as trading companies seek additional volumes in Brazilian seaports to complete shipments for export. A change in Chicago Board of Trade (CBOT) differentials at the port of Paranagua was first observed on 27 September, when the premium for selling soybean oil for shipment in October rose to 8¢/lb in relation to the future contract traded on the CBOT. Earlier in the week, offers were close to 1.8¢/lb. On 25 September, negotiations ranged between premiums of 2.5-5.5¢/lb in relation to the soybean oil future contract due in October, corresponding to prices between $1,034-1,100/t fob Paranagua. Last week, the Argus fob Paranagua indicator closed between $934-1,009/t. Soybean availability in the Brazilian market is reduced amid strong demand in the domestic market, driven by an increase in the biodiesel blending mandate to 14pc from 12pc in March. The rise in domestic demand has also reduced the competitiveness of Brazilian exports, contributing to a drop in soybean oil shipments to ports. Brazil's association of vegetable oil industries Abiove predicts that 2024 exports will total 1.15mn t, nearly half of the volumes dispatched in 2023. Lever effect The low availability of soybean oil in the Brazilian market was concerning market participants even before the deterioration of the situation in Argentina. The price of soybean oil for export is the main factor in the price equation for most supply contracts between biodiesel producers and distributors. Logistics problems associated with a lower Parana River contribute to the imbalance between increased demand for soybean oil in the biodiesel sector and a shortage of product in the market. Soybean oil is the main input for biodiesel production in Brazil, accounting for 72.5pc of all feedstocks used in national production in the first eight months of 2024, according to data from hydrocarbons regulator ANP. And rising soybean oil prices tend to boost prices of other raw materials, such as beef tallow, which represented 6.5pc of biodiesel inputs in the same period. Faced with the rising cost of inputs, Brazilian biodiesel plants have been prioritizing the delivery of volumes contracted for the September-October supply period and the delivery of overdue volumes for the previous bi-monthly period. That has limited the availability of spot market volumes. This sudden rise in the price of soybean oil in Paranagua has also reduced the domestic market premium in relation to the export market. This makes it more attractive for regional producers to sell product abroad. By Amance Boutin and Joao Marinho Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Aug wildfires in Brazilian state surge eightfold
Aug wildfires in Brazilian state surge eightfold
Sao Paulo, 26 September (Argus) — Fires in Sao Paulo, Brazil's most populous state, increased eightfold in August from the same month last year, an "alarming rate" amid extreme climate conditions that harm the sugarcane industry, sector associations said. The state had 11,628 fire outbreaks last month, more than triple the historic average of 3,550. Nearly half of the fires took place on 23 August alone, according to data from industry association Canaoeste and fire monitoring network GMG Ambiental. Fires hit 658,600 hectares. The town of Pitangueira had the most blazes, at 354. Altinopolis and Sertaozinho came in second and third, with 252 and 296, respectively. Nearly all of the most affected towns have high production of sugarcane. The groups highlighted that 20-24 August fires happened as low humidity, high temperatures and strong winds put Sao Paulo in "extreme risk" for wildfires. The data was shown in a meeting with several industry representatives, such as Canoeste, Unica and Orplana. The groups added that sugarcane producers were not responsible for the fires nor were benefiting from them, defending themselves from accusations that they could be lighting fires to accelerate harvesting — an old common practice supposedly abolished. By Maria Ligia Barros Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Brazil's drought: Northern rivers still dropping
Brazil's drought: Northern rivers still dropping
Sao Paulo, 26 September (Argus) — The worst drought in Brazil's history continues to reduce river levels in the Northern Arc region, hampering navigation on rivers that are used as waterways and are important routes to transport grains and fertilizers. Madeira waterway The waterway links Rondonia state's capital Porto Velho to the Itacoatiara port, in Amazonas state. Itacoatiara port is expected to receive around 371,435 metric tonnes (t) of fertilizers in September, according to line up data from shipping agency Unimar. Status: The situation is most critical in the Madeira waterway, the second largest in the northern region, in Porto Velho. The state's ports and waterways authority (Soph) halted operations there on 23 September because the Madeira River's depth at the port reached 25cm (9.8in), the lowest since monitoring began in 1967. The Madeira River depth in Porto Velho increased to 34cm on 26 September, according to monitoring data from the Brazilian Geological Survey (SGB). Amazonas waterway It is the main waterway in Brazil's north, handling around 65pc of the region's cargo, according to the national transportation and infrastructure department (Dnit). It links Amazonas' capital Manaus to Para's capital Belem. Status: The Negro River has also been falling. The depth was at almost 13.88m at the SGB monitoring point in Manaus on 26 September — an extreme drought level and very close to the historic low of 13.64m recorded in 2023. Tapajos waterway It is an important waterway to move production from Mato Grosso state's northern area, with the Santarem port, in Para state, as a destination. The Santarem port handled nearly 4mn t of cargo in 2023, with fertilizers accounting for 578,630t, according to the Para port authority. Status: The Tapajos-Teles Pires waterway is also facing a dire situation. The national water and sanitation agency ANA declared a water shortage on the Tapajos River on 23 September. Drier weather than usual has dropped the levels of Tapajos, especially in the stretch between Itaituba and Santarem cities, in Para state, where flows are below the minimum levels observed in history. The depth of the Tapajos River at the Itaituba monitoring point, where the transfer point for the Miritituba waterway is located, was at 92cm on 26 September, below the record low of 132cm, according to SBG data. At the Santarem monitoring point, where the port of Santarem is located, the Tapajos River was at 74cm, a level considered dry. The historical minimum at the location is -55cm below the port's reference point. A level below zero does not mean the river is dry, but a negative reading indicates very low conditions. Tocantins-Araguaia waterway The Tocantins-Araguaia waterway encompasses the Araguaia and Tocantins rivers. It runs from the Barra do Garcas city, in Mato Grosso, onto the Araguaia River, or from Peixes city, in Tocantins state, onto the Tocantins River, to the port of Vila do Conde, in Para. Soybeans, corn, fertilizers, fuels, mineral oils and derivative products are transported via the northern waterways. Vila do Conde port handled 19.3mn t of cargo in 2023, according to Para port authority. Status: The SGB has two monitoring points on the Araguaia River. In the Nova Crixas city, in Goias state, the river was at 299cm, below the historical level of 310cm. In Sao Felix do Araguaia city, in Mato Grosso state, the river was at 257cm, a situation of extreme drought and close to the historical minimum level of 251cm. In September, the federal government announced investments of R500mn ($91.4mn) to carry out dredging work on stretches of rivers in Amazonas. Para's state government requested another R146mn to address problems caused by the drought. By João Petrini Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
US trucking index at 18-month high in August: ATA
US trucking index at 18-month high in August: ATA
Houston, 25 September (Argus) — US trucking freight volumes rose in August to the highest level since February 2023, the American Trucking Association (ATA) said. The ATA's seasonally adjusted Truck Tonnage Index (TTI) rose in August by 1.8pc from a month earlier and by 0.7pc from a year earlier. The index has increased on a monthly and yearly basis only twice in the past 18 months, last doing so in May 2024 . August's "robust gain" indicates freight levels are rebounding from a bottom, according to ATA economist Bob Costello. The TTI's month-to-month movement so far this year also shows the freight market is "at an inflection point," Costello said. The US trucking industry contracted in 2023 and initially got off to a slow start this year. Last week, the Federal Reserve cut its target lending rates for the first time in four years , suggesting the worst inflationary pressures may be over. The TTI is calculated monthly using a survey of ATA membership to estimate seasonally-adjusted trends in the value of US truck freight. Trucking comprises roughly three-quarters of tonnage carried by all modes of transportation in the US, and so can serve as an indicator of the health of the transportation sector and the economy at large. By Gordon Pollock Send comments and request more information at feedback@argusmedia.com Copyright © 2024. Argus Media group . All rights reserved.
Business intelligence reports
Get concise, trustworthy and unbiased analysis of the latest trends and developments in oil and energy markets. These reports are specially created for decision makers who don’t have time to track markets day-by-day, minute-by-minute.
Learn more